|
|
|
 Replacement Parts Catalog
OEM Replacement Parts Catalog
|
How can I replace my fuel pump?
Fuel pump installation varies greatly from various cars and trucks, and we recommend to ask in our car forum to find out for your specific application. Typically, the fuel pump sits right above the fuel tank, or on the side of the fuel tank, if it's external. If it's on the side, then you would need to access the pump from the bottom of the car. If it's on top, you would typically remove your rear seats, and find there is a cover. Once you remove the cover, you will find there are a few rubber hoses and a few electrical connectors. Unplug the harness, and remove the rubber hoses. Then, unbolt the little nuts that are holding down the fuel pump assembly, and slide out the fuel pump sideways, being careful not to catch the fuel screen on the tank. Most new fuel pumps come with a new fuel pump gasket, so you would want to replace this as well. Installation is the reverse of removal. For help and detailed instructions, please ask in our forum.
Do I also need to replace my fuel filter?
Whenever you replace the fuel pump, we always recommend to replace the fuel filter as a precaution. Many times the fuel pump fails because of contamination in the gas tank that ended up clogging the fuel pump. For these cases, it many times contaminates the fuel filter as well.
How can I tell if my fuel pump failed or is about to fail?
Usually, right before fuel pumps fail, they get much louder. A fuel pump sounds like a high pitched whine, as the little gears inside of the unit pump fuel to the engine. If a fuel pump is going to fail, the best time for it to fail is when the car is idling, or turned off. This way you can be sure that the engine is not requiring a lot of fuel pressure. If the fuel pump dies during high rpm operation, or when high fuel pressure is required, then it can cause catastrophic engine damage.
My car is modified, do I need a new fuel pump?
This question really depends on the modifications you have. If you have modifications that are causing your car to run lean, then you would need to ensure your fuel pump can maintain fuel pressure, and we would recommend a higher pressure fuel pump such as a Walbro fuel pump. If your car has simple modifications such as an intake, exhaust, or small mods, you can usually rely on the stock fuel system.
Do the fuel pumps you sell require any modifications when installing?
All of the fuel pumps we sell are direct replacements, and are exact specs as stock. Many times the fuel pumps are actually the stock pump that came in your car from the factory. There is no modification required, we guarantee it.
Latest BMW Fuel Pump Applications
 |
VDO Fuel Pump
- 87 BMW 325i Convertible M20 In Tank Fuel Pump |
 |
Pierburg Fuel Pump
02-05 BMW 745i N62 Right
In tank Fuel Pump |
 |
Bosch Fuel Pump
89-93 BMW 535i M30 0 580 464 995 One of two possible pumps may have been installed by BMW. See also part number 16 14 7 161 387. Customer must determine which pump is installed on car regardless of information listed in Bosch catalog or the OE CD-ROM. This pump has a small mounting bracket, and a banjo fitting. Note that this pump does not have an external pressure regulator as used in the Bosch pump. The Pierburg pump has an internal regulator. Fuel Pump |
 |
Pierburg Fuel Pump
89-93 BMW 535i M30 0 580 464 995 One of two possible pumps may have been installed by BMW. See also part number 16 14 7 161 387. Customer must determine which pump is installed on car regardless of information listed in Bosch catalog or the OE CD-ROM. This pump has a small mounting bracket, and a banjo fitting. Note that this pump does not have an external pressure regulator as used in the Bosch pump. The Pierburg pump has an internal regulator. Fuel Pump One of two possible pumps may have been installed by BMW. See also part number 16 14 7 161 387. Customer must determine which pump is installed on car regardless of information listed in Bosch catalog or the OE CD-ROM. This pump has a small mounting bracket, and a banjo fitting. Note that this pump does not have an external pressure regulator as used in the Bosch pump. The Pierburg pump has an internal regulator. |
 |
VDO Fuel Pump
85-87 BMW 735i M30 In Tank Fuel Pump |
 |
VDO Fuel Pump
06-06 BMW 325i Sedan N52 with Fuel Level Sensor Fuel Pump with Fuel Level Sensor |
 |
VDO Fuel Pump
99-00 BMW 328i Sedan M52 Right with level sensor Fuel Pump with level sensor |
|
Pierburg Fuel Pump
06-08 BMW 750Li N62TU Right
In tank Fuel Pump |
 |
Bosch Fuel Pump
85-87 BMW 325es M20 0 580 464 048 0 580 464 048 Fuel Pump |
 |
Pierburg Fuel Pump
85-87 BMW 325es M20 0 580 464 048 0 580 464 048 Fuel Pump |
 |
Bosch Fuel Pump
91-92 BMW 318i Convertible M42 In Tank The alternate Bosch # GFP 315 will only work with cars that were originally equipped with a Bosch pump. Some late models came with a Delco pump which is NOT interchangeable. This pump is a complete assembly with suction tubes and pick-up screen. GFP 315 is pump only! If equipped with Delco pump as original equipment, then this complete assembly is required. This pump assembly uses 62 16 8 782 015 for O-ring. Fuel Pump The in-tank fuel screen does not come with this unit & will NOT fit VDO the VDO pump. |
 |
VDO Fuel Pump
95-01 BMW 750iL M73 Fuel Pump |
|
VDO Fuel Pump
01-06 BMW 325Ci Coupe M54 Right with level sensor Fuel Pump with level sensor |
 |
Pierburg Fuel Pump
93-94 BMW 740iL M60 Fuel Pump |
|
Pierburg Fuel Pump
82-88 BMW 528e M20 0 580 464 048 Fuel Pump |
|
Bosch Fuel Pump
82-88 BMW 528e M20 0 580 464 048 Fuel Pump |
|
VDO Fuel Pump
01-05 BMW 325i Touring M54 Right with level sensor Fuel Pump with level sensor |
 |
Fuel Pump
91-93 BMW 850i M70 Left with fuel level sending unit only in conjunction with 16 11 1 179 637 gasket Fuel Pump with fuel level sending unit only in conjunction with 16 11 1 179 637 gasket |
 |
VDO Fuel Pump
01/95 - 08/95 BMW M3 S50 Right Fuel pump assembly complete with pick-up screen and fuel level sensor. Fuel Pump Fuel pump assembly complete with pick-up screen and fuel level sensor. |
|
Pierburg Fuel Pump
93-94 BMW 740i M60 Fuel Pump |
Some BMW Fuel Pump Applications (View Full Catalog Above)
| BMW 2002 |
BMW 318i Convertible |
BMW 318i Sedan |
| BMW 318is Coupe |
BMW 318ti |
BMW 320i |
| BMW 320i Sedan (Canada) |
BMW 323Ci Coupe |
BMW 323i Sedan |
| BMW 323is Coupe |
BMW 325Ci Coupe |
BMW 325e |
| BMW 325es |
BMW 325i Convertible |
BMW 325i Sedan |
| BMW 325i Touring |
BMW 325is Coupe |
BMW 325xi Sedan |
| BMW 328i Sedan |
BMW 328is Coupe |
BMW 330Ci Convertible |
| BMW 330Ci Coupe |
BMW 330i Sedan |
BMW 335i Coupe |
| BMW 335i Sedan |
BMW 525i |
BMW 525i Touring |
| BMW 528e |
BMW 528i |
BMW 530i |
| BMW 535i |
BMW 540i |
BMW 633CSi |
| BMW 635CSi |
BMW 735i |
BMW 740i |
| BMW 740iL |
BMW 745i |
BMW 745Li |
| BMW 750iL |
BMW 750Li |
BMW 840Ci |
| BMW 850i |
BMW M3 |
BMW M5 |
| BMW Z3 1.9 Roadster |
| M10 |
M20 |
M30 |
M42 |
M44 |
M50 |
M52 |
M54 |
| M60 |
M62 |
M70 |
M73 |
N52 |
N54 |
N62 |
N62TU |
| S50 |
S52 |
S54 |
S62 |
More Applications (View Full Catalog Above)
|
|
